59M系泊及航行试验大纲.docx
- 文档编号:8709641
- 上传时间:2023-05-14
- 格式:DOCX
- 页数:79
- 大小:67.88KB
59M系泊及航行试验大纲.docx
《59M系泊及航行试验大纲.docx》由会员分享,可在线阅读,更多相关《59M系泊及航行试验大纲.docx(79页珍藏版)》请在冰点文库上搜索。
59M系泊及航行试验大纲
59M多功能海上供应/操锚船
生产设计
PRODUCTIONDESIGN
标记
数量
修改单号
签字
日期
系泊及航行试验大纲
PROGRAMOFDOCKTRIAL
ANDSEATRIAL
SK89/90/91/92
编制
校对
审核
共54页total54
第 1页PAGE1
标检
福建省
白马船厂
船舶科学研究所
批准
日期
目次
0试验的一般要求,准备及组织7
GENERALREQUIREMENTS,PREPARATIONANDORGANIZATIONOFTESTS7
1.0甲板机械和设备系泊试验总则7
GENERALREQUIREMENTSOFDOCKTRIALSFORDECKMACHINERY&EQUIPMENTS7
1.1试验项目:
锚设备及锚机试验8
TESTITEM:
TestofAnchorEquipmentandWindlass8
1.2试验项目:
舵设备及舵设备试验8
TESTITEM:
Testofsteeringgearandrudderunit8
1.3试验项目:
救生设备试验9
TESTITEM:
InspectionandTestofLife-saving9
1.4试验项目:
系缆及拖曳装置的检查及试验10
TESTITEM:
Hawserandtowingunitcheckoutandtest10
1.5试验项目:
起货设备试验11
TESTITEM:
Liftingdevicetest11
1.6试验项目:
门、窗及其它开口关闭装置试验12
TESTITEM:
Inspectionandtestdoors,Windowsanddevices12
1.7试验项目:
信号设备试验13
TESTITEM:
Inspectionandtestofsignalequipment13
1.8试验项目:
消防设备的检查和实验13
TESTITEM:
Inspectionandtestoffire-fightingequipment13
1.9试验项目:
传令设备检查13
TESTITEM:
checkthetelegraph13
2.0试验项目:
主机14
TESTITEM:
MainEngine14
2.1试验项目:
变距桨及轴系15
TESTITEM:
Varyingpitchpropeller&Shaft15
2.2试验项目:
轴带发电机16
TESTITEM:
INSPECTION&TESTOFShaftAlternators16
2.3试验项目:
柴油发电机组17
TESTITEM:
INSPECTION&TESTOFGen.Sets17
2.4试验项目:
应急柴油发电机21
TESTITEM:
EmergencyGen.Set21
2.5试验项目:
主配电板的试验检查22
TESTITEM:
Mainswitchboardtest22
2.6试验项目:
应急配电板试验24
TESTITEM:
Emergencyswitchboardtest24
2.7试验项目:
空压机和空气瓶25
TESTITEM:
Aircompressor&receiver25
2.8试验项目:
电动泵的运转试验25
TESTITEM:
Thetestofpumps25
3.0试验项目:
分油机(厂商参与下进行)26
TESTITEM:
Purifier(manufacturermustbeonthescene)26
3.1试验项目:
舱底水油水分离器的效用试验27
TESTITEM:
Theeffectivetestofoilwaterseparator27
3.2试验项目:
生活污水处理装置试验28
TESTITEM:
Thetestofdomesticsewagetreatmentplant28
3.3试验项目:
压力水柜单元效用试验29
TESTITEM:
Waterpressuretanktest29
3.4试验项目:
系统试验29
TESTITEM:
Thetestofsystem30
3.5试验项目:
充放电板及蓄电池试验32
TESTITEM:
Checktheaccuracyandcompletenessoftheinstallationofchainhhoists32
3.6试验项目:
测量热态绝缘电阻33
TESTITEM:
Measuretheinsulationresistanceinhotcondition33
3.7试验项目:
其它设备电气控制部分效用试验33
TESTITEM:
theeffectivenesstestfortheelectriccontrolunitofequipments33
3.8试验项目:
火灾探测和报警系统试验33
TESTITEM:
Firedetectionandalarmsystemtest33
3.9试验项目:
机械和箱柜舱室液位报警系统试验34
TESTITEM:
Machineryroomlevelalarmsystemtest34
4.0试验项目:
风油遥切效用试验34
TESTITEM:
Carryouttheeffectivenesstestforventilatorandoilpumpcutoff.34
4.1试验项目:
前,后驾控台面板上各有关控制开关34
TESTITEM:
Operatevariousrelatedcontrolswitch34
4.2试验项目:
无线电设备34
TESTITEM:
Radio34
4.3试验项目:
航行设备35
TESTITEM:
Navigationdevice35
4.4试验项目:
船内通讯37
TESTITEM:
Innercommunication37
4.5试验项目:
闭路电视系统37
TESTITEM:
Closedcircuittelevisionsystem37
4.6试验项目:
航行试验总则38
TESTITEM:
GENERALREQUIREMENTSOFSEATRIALS38
4.7试验项目:
抛锚试验39
TESTITEM:
Anchoringtest39
4.8试验项目:
操舵试验40
TESTITEM:
Steeringtest40
4.9试验项目:
航向稳定试验40
TESTITEM:
Coursesteadytest40
5.0试验项目:
回转试验41
TESTITEM:
Turningcircletest41
5.1试验项目:
惯性停船试验41
TESTITEM:
Inertiatest41
5.2试验项目:
紧急停船试验41
TESTITEM:
Emergencystoptest41
5.3试验项目:
航速测定41
TESTITEM:
Speedtest41
5.4试验项目:
侧推装置试验42
TESTITEM:
Bowthrustertest42
5.5试验项目:
紧急操船试验43
TESTITEM:
Emergencymaneuveringtest43
5.6试验项目:
主机遥控系统试验43
TESTITEM:
Remotecontrolsystemtestformainengine43
5.7试验项目:
主机运转试验44
TESTITEM:
Mainenginerunningtest44
5.8试验项目:
轴系试验45
TESTITEM:
Shaftingtest45
5.9试验项目:
主机油耗测量(如果船东有要求)45
TESTITEM:
Oilconsumptionmeasurementformainengine(IFTHEOWNERREQUEST)45
6.0试验项目:
可变螺距螺旋桨及其操纵装置的试验45
TESTITEM:
Theadjustablepitchpropelleranditsmaneuveringplanttest45
6.1试验项目:
海水淡化系统46
TESTITEM:
Seawaterdesaltingsystem46
6.2试验项目:
柴油发电机组和轴带发电机组运行试验46
TESTITEM:
Testofdieseloilgeneratingset46
6.3试验项目:
Fi-Fi泵试验47
TESTITEM:
Fi-Fipumptest47
6.4试验项目:
无线电设备47
TESTITEM:
radio47
6.5试验项目:
航行设备48
TESTITEM:
Navigationequipment48
6.6试验项目:
船内通信49
TESTITEM:
Innercommunication49
6.7试验项目:
闭路电视49
TESTITEM:
Closedcircuittelephone49
6.8试验项目:
DP动力定位系统校检及试验49
TESTITEM:
Inspection&TestofDPsystem49
6.9试验项目:
噪音测试49
TESTITEM:
Noiseleveltest49
7.0试验项目:
冷藏、空调、通风系统试验大纲50
TESTITEM:
Chiller/Freezer,air-con.&ventilationssystemtest50
8瘫船试验流程53
DEADSHIPTESTPROCESS53
8.1瘫船试验的条件和要求53
Deadshiptestconditionsandrequirement53
8.2试验步骤53
Teststeps53
0试验的一般要求,准备及组织
GENERALREQUIREMENTS,PREPARATIONANDORGANIZATIONOFTESTS
0.1本大纲包括系泊试验及航行试验,各项目的试验程序由造船部决定。
Thisprogramcoversoperationtestsandacceptanceduringdocktrialsandseatrials,Thesequenceofeveryitemisdeterminedbythemanagementresponsiblefortheconstructionofvessel.
0.2在各项目试验开始前,各有关人员应该熟悉该项设备的使用说明书以及相关的施工设计图纸和技术规格数中的内容。
Priortostartingoftests,personsinvolvedshouldmakethemselvesfamiliarwithoperationinstructionsandrelevantshipdesigndrawingsanddemandintechnicalspecification.
0.3本大纲所包括的各设备以及相关的各系统可以同时进行试验。
Thisprogramcoverssimultaneoustestsoftheequipmentinvolvedtogetherwiththeactingjointlyssystem.
0.4试验由船级社验船师验收的项目,试验记录参数须经船师验的认可。
Recordofdelivery-acceptancetestsaretobewitnessedandsatisfiedbyclassificationsurveyor.
0.5各项试验应在船东代表参加下进行。
Allthetestsshouldbewitnessedbyowner’srepresentativeswhentheyardheld.
0.6试验结果由船厂质管处检验员记录于规定的表格上。
Theresultsoftestswillberecordedinstipulatedformsbysurveyorofshipyard’squalitycontroldepartment.
0.7有关部门参加试验的通知:
试验时间最少应提前一天通知相关的参试人员。
试航的大约时间应该在试航开始前20天通知船东,确切日期应该于试验前7天确定,并且通知船东和“ABS”验船师。
Noticegiventoconcernedpartiesanddepartmentstoattendthetest:
Incaseofthetestswillbeheldontime,noticeshouldbegivenatleastonedaybeforethetestingday.
Noticeaboutapproximateseatrialdateshouldbesubmittedtotheowner20daysbeforethetrial15duetobeginandthefixdateshouldbeconfirmedbytheshipyardnotlaterthan7daysbeforebeginningoftrialsandbeinformedtotheownerandABSsurveyor.
0.8试验过程中应注意安全措施。
Securityarrangementmustbenoticedwhiletesting.
1.0甲板机械和设备系泊试验总则
GENERALREQUIREMENTSOFDOCKTRIALSFORDECKMACHINERY&EQUIPMENTS
1.0.1本项目包括全船甲板机械及相关部分设备的系泊试验。
Thisitemconsistofthedocktrialforalldeckmachineryandrelevantequipment.
1.0.2本项目所有系统以及设备试验之前应检查其系统的安装是否与图纸一致,并安装完整。
Checkthecompletenessoftheinstallationofsystemswhichareincompliancewiththedrawingsbeforethetestsofallsystemsandequipment.
1.0.3各系统以及设备的机械、液压和电气部分应同时进行试验,并做记录。
Carryoutthetestofmechanical,hydraulicandelectricpartofeachsystemandequipmentsimultaneouslyandrecordtheresults.
1.1试验项目:
锚设备及锚机试验
TESTITEM:
TestofAnchorEquipmentandWindlass
1.1.1锚设备检查Inspectionoftheanchorequipment
检查锚机、锚链、锚及掣链器等设备安装的完整性,并审查锚机、锚链和锚的合格证。
检查锚机座等的焊接情况。
Inspectionshallbemadetoensuretheinstallationoftheanchorequipmentincludingthewindlass,chaincable,anchorandchain-stopper.Checkthelicenseofanchorwindlass,chainandanchor.Checktheweldingforthefoundationofanchorwindlass,etc.
1.1.2空载运转试验Windlasslight-loadrunningtest
锚机进行正、倒车空载连续全速运转各30min,试验时每隔2min正、倒车变换一次,观察传动装置及各运动部件有无异常发热及敲击现象。
Thetestshallbecontinuedforhalfhour.Duringthetest,thewindlassshallbechangedrunningdirectionevery2minutesfromrunningaheadtoasternandrunningasterntoahead.Makesurethewindlassworkproperlywithoutanyabnormal.
1.1.3检查每根锚链标记、根部固定情况并作弃锚装置脱钩试验,然后收起,检查锚链在锚链舱内的堆放情况。
Checkthemarkofeachchainandrootsecuring.Dothehookreleasingtestfortheanchorreleasingunit.Restorethechain,checkthechainstoragestatusinthechainlocker.
1.2试验项目:
舵设备及舵设备试验
TESTITEM:
Testofsteeringgearandrudderunit
1.2.1检验舵机及操舵系统安装的完整性,并审查舵机合格证及有关文件。
Inspectionshallbemadetoensurethesteeringgearandmaneuveringsystemarebothproperly.Checkthelicenseandrelativedocumentsofsteeringgear.
1.2.2检查舵角指示器与舵叶之间的误差,检查时自中间位置向两舷转舵,舵角每增加5°核对一次,并作记录。
舵叶与舵角指示器之间误差应≤±1°,且正舵(即0°)应无误差。
Inspectionshallbemadetocheckthedifferencebetweentherudderangleindicatorandrudderblade.Movingtherudderfromthecentralpositiontoeachsideat5°step,checkonceandrecordit.Thedifferencebetweentherudderangleindicatorandrudderbladeshouldbenotmorethan±1°;whenat0°,thereshouldbenodifference.
1.2.3检查舵角电气限位装置的动作正确性,应能使舵叶转至左、右舷各35°处停止。
检查机械限位器动作的正确性。
Inspectionshallbedonetomakesureproperworkingoftheelectriclimitinggear.Itshalleffectivelystoptherudderat35°position.
1.2.4连续操舵试验Continuoussteeringtest
试验期间每套动力源、每套控制系统及每套液压泵单元均应连续运转不少于30min,并分别在驾驶室和舵机间操舵15min。
测试期间,检查电气设备、液压泵单元及其它各系统的工作情况。
试验应在0°--左(右)35°--0°--右(左〉35°--0°交替进行,并应不少于10个循环。
并测定自一舷35°转至另一舷30°所需时间,该时间应不大于28s。
Forthistest,eachpowersource,eachcontrolsystemandpumpunitsshallruncontinuouslyfornotlessthan30minutes.Theoperationshallbeconductedfromthewheelhouseandsteeringgearcompartmentrespectivelyfor15minutes,Duringthetestworkingstateofalltheelectricequipment,pumpunitsandsystemshouldbechecked,Thetestshallbedonewiththeruddermovefrom0°positionto35°positionport(starboard),backto0°positionandto35°positionstarboard(port),repeatedforatleast10timesformeasuringthetimeneededformovetherudderfrom35positiononesideto30°positionotherside,andthetimeshallbenotmorethan28s.
1.2.5检查各报警项目的有效性和可靠性。
Checktheeffectivenessandreliabilityofeachalarm.
1.2.6测量各电动机,控制箱的热态绝缘电阻应不低于1MΩ。
Measuretheinsulationresistanceinhotconditionofeachmotorandcontrolboxwhichisnotlessthan1MΩ.
1.3试验项目:
救生设备试验
TESTITEM:
InspectionandTestofLife-saving
1.3.1检查救生设备的布置、安装、数量和种类是否符合批准的设计图
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 59 系泊 航行 试验 大纲
![提示](https://static.bingdoc.com/images/bang_tan.gif)